飞行器结构噪声致振试验及声振耦合响应分析

张国军; 闫云聚; 李鹏博

doi:10.3879/j.issn.1000-0887.2013.11.005

飞行器结构噪声致振试验及声振耦合响应分析

doi: 10.3879/j.issn.1000-0887.2013.11.005

西北工业大学力学与土木建筑学院, 西安 710129

基金项目: 教育部博士点专项基金资助项目（20126102130004）

详细信息

作者简介:
张国军(1979—),男,陕西人,博士生(通讯作者. E-mail: zgj2004@163.com).

中图分类号: O355;TB53
计量
- 文章访问数: 1060
- HTML全文浏览量: 75
- PDF下载量: 1419
- 被引次数: 0
出版历程
- 收稿日期: 2013-07-05
- 修回日期: 2013-09-12
- 刊出日期: 2013-11-15

Noise-induced Vibration Experiment of Aircraft Structure and Vibro-Acoustic Coupling Response Analysis

School of Mechanics, Civil and Architecture, Northwestern Polytechnical University, Xi’an 710129, P.R.China

Funds: The National Natural Science Foundation of China;The National Basic Research Program of China (973 Program)

摘要

摘要: 以高超声速飞行器X-43A为研究对象，建立其有限元结构模型，在动力学实验室进行飞行器结构模型的固有频率测试，通过固有频率计算与试验结果对比，二者误差在1%左右，这表明所建立的结构有限元模型是比较准确的．在高声强混响室进行飞行器结构噪声致振试验，得到飞行器结构测点加速度功率谱密度(power spectral density, PSD)和舱内声场噪声声压级，通过声振耦合数值模拟计算结果与试验值对比，结果表明：数值模拟计算方法对振动噪声环境预测是比较可靠的，结构振动响应与舱内噪声响应的有限元分析与试验结果趋势上较为一致，低频段吻合较好；高频外噪声场引起的飞行器弹性腔体结构振动占据结构振动响应的主要成分，尤其是以结构低阶振动为主，而外噪声场传递到封闭腔体内的噪声也主要是通过结构腔体弹性壁板的低阶振动传播，即使外噪声激励是宽频的，封闭舱内响应噪声的频率主分量仍然是结构的低阶模态振动．
- 飞行器 /
- 声振试验 /
- 声振耦合 /
- 试验验证
Abstract: Aimed at the hypersonic aircraft X-43A in the research, the FE model was established. Natural frequency testing of the aircraft structure model was performed. The numerical values of natural frequency were compared with the experiment results, with errors at about 1%, which showed that the FE model of the aircraft was correct. A noise-induced vibration experiment of the aircraft model was completed in the high intensity sound laboratory, which could obtain the results of PSD and noise pressure. Comparison of the simulation values with the experiment results shows that the method of numerical simulation is reliable in prediction of the vibration and noise environment of the aircraft cabin. The trend of the numerical vibro-acoustic response is well consistent with that of the test results: there is little difference in low-frequency range the elastic cavity structural vibration of the aircraft model caused by high-frequency noise field outside the cavity makes the main components of structural vibration, especially of the low-order structural vibration. Noise in the aircraft cabin transmitted from the outer noise field is through the low-order vibration of the aircraft shell. The main components of the response noise frequencies in the closed cabin belong to structural low-order modal vibration, even if the noise excitation outside the cabin is broadband.
- aircraft /
- noise-induced vibration experiment /
- vibro-acoustic response /
- experimental verification

HTML全文

参考文献(8)

[1]	王其政, 刘斌, 宋文滨. 航天事故与动力学环境预示和控制技术研究述评[J]. 环境技术, 1995, 29(4): 1-6.(WANG Qi-zheng, LIU Bin, SONG Wen-bin. Aerospace failure and survey of prediction and control technique of dynamic environment[J].Environmental Technology,1995, 29(4): 1-6.(in Chinese))
[2]	王昆.飞行器结构统计能量建模方法及声振响应分析研究[D]. 硕士学位论文. 哈尔滨工业大学, 2010.(WANG Kun. The research of modeling of aircraft structures by SEA and vibroacoustic analysis[D]. Master Thesis. Harbin: Harbin Institute of Technology, 2010.(in Chinese))
[3]	胡选利, 陈花玲, 赵建平. 声振耦合数值模型合理性分析和实验验证[J]. 西安交通大学学报, 1997, 31(7): 1-6.(HU Xuan-li, CHEN Hua-ling, ZHAO Jian-ping. Rationalization and experiments of current vibroacoustic analytical models[J].Journal of Xi’an Jiaotong University,1997, 31(7): 1-6.(in Chinese))
[4]	尹立中, 徐孝诚, 谭志勇. 再入飞行器壳体气动噪声响应分析和试验验证[J]. 强度与环境, 2002, 29(2): 5-9.(YIN Li-zhong, XU Xiao-cheng, TAN Zhi-yong. Response analysis and experimental verification for reentry vehicle shell subjected to aerodynamic noise[J].Structure and Environment Engineering,2002, 29(2): 5-9.(in Chinese))
[5]	孙目, 王小军, 潘忠文, 王明宇. 统计能量分析在飞行器动力学环境预示中的应用[J]. 导弹与航天运载技术, 2009, 301(3): 11-14.(SUN Mu, WANG Xiao-jun, PAN Zhong-wen, WANG Ming-yu. Applications of statistical energy analysis in prediction of flight dynamics environment[J].Missiles and Space Vehicles,2009, 301(3): 11-14.(in Chinese))
[6]	尹忠俊, 岳恒昌, 陈兵, 王文瑞, 赵爱民. 基于统计能量法的排气管道系统的振动和噪声分析与研究[J]. 振动与冲击, 2010, 29(2): 159-162.(YIN Zhong-jun, YUE Heng-chang, CHEN Bing, WANG Wen-rui, ZHAO Ai-min. Vibration and noise analysis of an exhaust piping system based on statistical energy analysis[J].Journal of Vibration and Shock,2010, 29(2): 159-162.(in Chinese))
[7]	Desmet W, Sas P, Vandepitte D.Numerical Acoustics Theoretical Manual [M]. Leuven: LMS International, 2000.
[8]	张国军, 闫云聚, 李鹏博. 用统计能量法分析飞行器声振响应影响因素[J]. 空军工程大学学报(自然科学版), 2013, 14(2): 23-27.(ZHANG Guo-jun, YAN Yun-ju, LI Peng-bo. Applications of statistical energy analysis in influencing factors analysis of aircraft vibro-acoustic response characteristics[J].Journal of Air Force Engineering University( Natural Science Edition),2013, 14(2): 23-27.(in Chinese))